Estudos Sobre a Formação de Hidratos em Fluidos de Perfuração à Base Água - Revisão / Studies on Hydrate Formation in Water Based Drilling Fluids - Review

Authors

  • Andre Luis Petroro
  • Tainan Gabardo Miranda dos Santos
  • Jonathan Felipe Galdino
  • Cezar Otaviano Ribeiro Negrão

DOI:

https://doi.org/10.34117/bjdv7n12-567

Keywords:

Hidrato, THF, Reologia, Fluidos de perfuração.

Abstract

Com o aumento da exploração offshore  de petróleo em regiões ultra profundas, como a região do pré-sal, os desafios da perfuração de poços aumentam. A pressão e a temperatura dos reservatórios nestas regiões podem atingir valores superiores à 100 MPa e 150 °C, respectivamente. Durante o processo de perfuração, a mistura de gases da formação com o fluido de perfuração podem ocorrer. Entretanto, a temperatura no fundo do mar é de aproximadamente 4 °C. Em tais condições, elevada pressão e baixa temperatura, a formação de hidratos é favorecida quando o fluido de perfuração entra em contato com o gás do reservatório. A formação de hidratos também pode ocorrer no transporte do petróleo para a costa terrestre via oleodutos. Quando formados, os hidratos podem criar plugues, obstruir as linhas e interromper o fluxo, reduzir a produtividade, danificar equipamentos, válvulas, tubulações e comprometer a segurança. Significativos investimentos são realizados pela indústria do petróleo para prevenir ou gerenciar a formação de hidratos. Neste trabalho foi realizada uma revisão bibliográfica referente ao contexto histórico dos estudos envolvendo a formação de hidratos e os estudos que utilizaram fluidos à base água, contendo THF como agente formador de hidratos. Nos trabalhos revisados, foram apresentadas as propriedades mecânicas, físicas e quiímicas de hidratos. Foi investigado a eficácia de diferentes inibidores – substâncias que previnem e/ou retardam a formação de hidratos no processo de exploração e transporte de petróleo. Foi constatado a necessidade de novos estudos referente à região de metaestabilidade, região que apresenta condições termodinâmicas favoráveis de temperatura e pressão para o início da nucleação e crescimento de cristais de hidrato.

References

Santos, O. L. A., 2006, “Segurança de Poços Em Lâminas de Água Ultraprofundas,” ENAHPE 2006 – Encontro Nacional de Hidráulica de Perfuração e Completação de Poços de Petróleo e Gás, Pedra Azul, Domingos Martins – ES.

Braga, M., Fernando, L., and Rossi, S., 2012, “Análise Termodinâmica Da Formação De Hidratos De Gás Metano Sob Ação De Inibidores Salinos,” Rev. Eng. e Tecnol., 4, pp. 1–10.

Sloan Jr., E. D., and Koh, C. A., 2008, Clathrate Hydrates of Natural Gases, Editora CRC Press.

Hester, K. C., and Brewer, P. G., 2009, “Clathrate Hydrates in Nature,” Ann. Rev. Mar. Sci., 1(1), pp. 303–327.

Sloan, D., Koh, C. A., Sum, A. K. ., Ballard, A. L. ., Creek, J., Michael;, E., Lachance, J. W. ., McMullen, N., Palermo, T., Shoup, G., and Talley, L., 2011, “Natural Gas Hydrates in Flow Assurance,” Natural Gas Hydrates in Flow Assurance, Gulf Professional Publishing is an imprint of Elsevier, p. 200.

Mühlstedt, G., 2017, “Estudo Experimental Da Formação e Crescimento de Hidratos de Tetrahidrofurano Em Uma Célula Cilíndrica,” Universidade Tecnológica Federal Do Paraná.

Sloan Jr., E. D., and Koh, C. A., 2007, Clathrate Hydrates of Natural Gases, CRC Press.

Davy, H., 1811, “The Bakerian Lecture. On Some of the Combinations of Oxymuriatic Gas and Oxygene, and on the Chemical Relations of These Principles, to Inflammable Bodies.,” Philos. Trans. R. Soc. London, 101(3), pp. 1–35.

Hammerschmidt, E. G., 1934, “Formation of Gas Hydrates in Natural Gas Transmission Lines.,” Ind. Eng. Chem., 26(8), pp. 851–855.

Sloan, D., Koh, C. A., Sum, A. K. ., Ballard, A. L. ., Creek, J., Michael;, E., Lachance, J. W. ., McMullen, N., Palermo, T., Shoup, G., and Talley, L., 2011, “Natural Gas Hydrates in Flow Assurance,” Gulf Professional Publishing is an imprint of Elsevier, p. 200.

Martins, L. R. S., 2003, “Hidratos de Metano: Um Interesse Crescente,” Gravel, (1), pp. 131–135.

Klauda, J. B., and Sandler, S. I., 2005, “Global Distribution of Methane Hydrate in Ocean Sediment,” Energy & Fuels, 19(2), pp. 459–470.

FARADAY, M., 1823, “On Fluid Chlorine,” Philos. Trans. Soc., 160, p. 189.

Deaton, W. M., and Jr. Frost, E. M., 1946, “Gas Hydrates and Their Relation to the Operation of Natural Gas Pipe Lines,” U.S. Bur. Mines Monogr., 8.

Kvenvolden, K. A., and Lorenson, T. D., 2001, “The Global Occurrence of Natural Gas Hydrate,” Natural Gas Hydrates: Occurrence, Distribution, and Detection. Geophys. Monogr. Ser., W.P. Paull, CK; Dillon, ed., Washington, D.C., pp. 3–18.

Milkov, A. V., 2005, “Molecular and Stable Isotope Compositions of Natural Gas Hydrates: A Revised Global Dataset and Basic Interpretations in the Context of Geological Settings,” Org. Geochem., 36(5), pp. 681–702.

Krey, V., Canadell, J. G., Nakicenovic, N., Abe, Y., Andruleit, H., Archer, D., Grubler, A., Hamilton, N. T. M., Johnson, A., Kostov, V., Lamarque, J.-F., Langhorne, N., Nisbet, E. G., O’Neill, B., Riahi, K., Riedel, M., Wang, W., Yakushev, V., O’Neill, B., Riahi, K., Riedel, M., Wang, W., and Yakushev, V., 2009, “Gas Hydrates: Entrance to a Methane Age or Climate Threat?,” Environ. Res. Lett., 4(3), p. 34007.

THOMAS, J. E., 2004, Fundamentos de Engenharia de Petróleo, Rio de Janeiro - Interciência.

Collett, T., Bahk, J.-J., Frye, M., Goldberg, D., Husebo, J., Koh, C., Malone, M., Shipp, C., and Torres, M., 2013, Historical Methane Hydrate Project Review, Washington D.C.

Makogon, Y. F., Holditch, S. A., and Makogon, T. Y., 2007, “Natural Gas-Hydrates — A Potential Energy Source for the 21st Century,” J. Pet. Sci. Eng., 56(1–3), pp. 14–31.

Makogon, Y. F., 2010, “Natural Gas Hydrates – A Promising Source of Energy,” J. Nat. Gas Sci. Eng., 2(1), pp. 49–59.

Gudmundsson, J. S., Hveding, F., and Boerrehaug, A., 1995, “Transport of Natural Gas as Frozen Hydrate,” 5. Int. Conf. Offshore Polar Eng., 1, p. 646.

Chong, Z. R., Yang, S. H. B., Babu, P., Linga, P., and Li, X. Sen, 2016, “Review of Natural Gas Hydrates as an Energy Resource: Prospects and Challenges,” Appl. Energy, 162, pp. 1633–1652.

Peixinho, J., Karanjkar, P. U., Lee, J. W., and Morris, J. F., 2010, “Rheology of Hydrate Forming Emulsions,” Langmuir, 26(14), pp. 11699–11704.

Ahuja, A., 2015, “Hydrate Forming Emulsion : Rheology and Morphology Analysis for Flow Assurance,” The City University of New York.

Gough, S. R., and Davidson, D. W., 1971, “Composition of Tetrahydrofuran Hydrate and the Effect of Pressure on the Decomposition,” Can. J. Chem., 49(16), pp. 2691–2699.

Devarakonda, S., Groysman, A., and Myerson, A. S., 1999, “THF–Water Hydrate Crystallization: An Experimental Investigation,” J. Cryst. Growth, 204(4), pp. 525–538.

Delahaye, A., Fournaison, L., Marinhas, S., Chatti, I., Petitet, J. P., Dalmazzone, D., and Fürst, W., 2006, “Effect of THF on Equilibrium Pressure and Dissociation Enthalpy of CO 2 Hydrates Applied to Secondary Refrigeration,” Ind. Eng. Chem. Res., 45(1), pp. 391–397.

Anderson, R., Chapoy, A., and Tohidi, B., 2007, “Phase Relations and Binary Clathrate Hydrate Formation in the System H 2-THF-H2O,” Langmuir, 23(6), pp. 3440–3444.

Giavarini, C., and Hester, K., 2011, Gas Hydrates: Immense Energy Potential and Environmental Challenges.

Liu, Y., Song, Y., Chen, Y., Yao, L., and Li, Q., 2010, “The Detection of Tetrahydrofuran Hydrate Formation and Saturation Using Magnetic Resonance Imaging Technique,” J. Nat. Gas Chem., 19(3), pp. 224–228.

Iida, T., Mori, H., Mochizuki, T., and Mori, Y. H., 2001, “Formation and Dissociation of Clathrate Hydrate in Stoichiometric Tetrahydrofuran-Water Mixture Subjected to One-Dimensional Cooling or Heating,” Chem. Eng. Sci., 56(16), pp. 4747–4758.

Larsen, R., Knight, C. A., and Sloan, E. D., 1998, “Clathrate Hydrate Growth and Inhibition,” Fluid Phase Equilib., 150–151(0378), pp. 353–360.

Pinder, K. L., 1965, “A Kinetic Study of the Formation of the Tetrahydrofuran Gas Hydrate,” Can. J. Chem. Eng., 43(5), pp. 271–274.

Pinder, K. L., 1965, “Viscosity of the Tetrahydrofuran-Water System,” Can. J. Chem. Eng., 43(5), pp. 274–275.

Parameswaran, V. R., Paradis, M., and Handa, Y. P., 1989, “Strength of Frozen Sand Containing Tetrahydrofuran Hydrate,” Can. Geotech. J., 26(3), pp. 479–483.

Ashworth, T., Johnson, L. R., and Lai, L. P., 1985, “Thermal Conductivity of Pure Ice and Tetrahydrofuran Clathrate Hydrates.,” 17, pp. 413–419.

Makogon, T. Y., Larsen, R., Knight, C. A., and Sloan, E. D., 1997, “Melt Growth of Tetrahydrofuran Clathrate Hydrate and Its Inhibition: Method and First Results,” J. Cryst. Growth, 179(1–2), pp. 258–262.

Bai, Y., and Bai, Q., 2010, “Subsea Engineering Handbook,” Subsea Eng. Handb.

Krivchikov, A. I., Manzhelii, V. G., Korolyuk, O. A., Gorodilov, B. Y., and Romantsova, O. O., 2005, “Thermal Conductivity of Tetrahydrofuran Hydrate,” Phys. Chem. Chem. Phys., 7(5), p. 728.

Ogata, K., Hashimoto, S., Sugahara, T., Moritoki, M., Sato, H., and Ohgaki, K., 2008, “Storage Capacity of Hydrogen in Tetrahydrofuran Hydrate,” Chem. Eng. Sci., 63(23), pp. 5714–5718.

Wang, W., Fan, S., Liang, D., and Li, Y., 2010, “Experimental Study on Flow Characteristics of Tetrahydrofuran Hydrate Slurry in Pipelines,” J. Nat. Gas Chem., 19(3), pp. 318–322.

Alavi, S., and Ripmeester, J. A., 2012, “Effect of Small Cage Guests on Hydrogen Bonding of Tetrahydrofuran in Binary Structure II Clathrate Hydrates,” J. Chem. Phys., 137(5).

de Lima Silva, P. H., Naccache, M. F., de Souza Mendes, P. R., Campos, F. B., Teixeira, A., and Sum, A. K., 2017, “Rheology of Tetrahydrofuran Hydrate Slurries,” Energy & Fuels, 31(12), pp. 14385–14392.

Zhang, H., Du, J., Wang, Y., Lang, X., Li, G., Chen, J., and Fan, S., 2018, “Investigation into THF Hydrate Slurry Flow Behaviour and Inhibition by an Anti-Agglomerant,” RSC Adv., 8(22), pp. 11946–11956.

Koh, C. A., Sloan, E. D., Sum, A. K., and Wu, D. T., 2011, “Fundamentals and Applications of Gas Hydrates,” Annu. Rev. Chem. Biomol. Eng., 2(1), pp. 237–257.

Published

2021-12-29

How to Cite

Petroro, A. L., Santos, T. G. M. dos, Galdino, J. F., & Negrão, C. O. R. (2021). Estudos Sobre a Formação de Hidratos em Fluidos de Perfuração à Base Água - Revisão / Studies on Hydrate Formation in Water Based Drilling Fluids - Review. Brazilian Journal of Development, 7(12), 118633–118652. https://doi.org/10.34117/bjdv7n12-567

Issue

Section

Original Papers